Reader asks about using unleaded fuel in an old car

Reader asks about using unleaded fuel in an old car

View CaptionHide Caption
Using a lead substitute is only needed if driving a 1970 or older vehicle under a heavy load or at high speed. James Halderman photo

Wheels:

Dave H. writes by email: “My wife and I own a ’57 T-bird. The owner’s manual ‘recommends’ using a premium-grade fuel (which, of course, would have been leaded fuel in 1957). I understand that gasoline octane ratings are calculated differently now than they were in the ’50s, and I also don’t know what octane rating would have been considered to be ‘premium’ in the ’50s. Given the changes in fuel formulations over the years, most notably the addition of ethanol and the removal of lead, would you say that I should still use a premium-grade fuel, or would today’s regular grade now be satisfactory?

Also, the vehicle was restored before we got it, so I don’t know if any engine modifications were made to accommodate unleaded fuel. Consequently, I always add a lead substitute to every tank fill-up. In the event the necessary modifications were, in fact, done before we purchased the car, other than adding unnecessary air pollution, is there any harm being caused by adding lead substitute to the fuel at every fill-up?”

Halderman: The best way to find out how the gas works is to try using first midgrade (Plus) and see if the engine pings under a load when it is hot. When the engine “pings”, it sounds like loose marbles in a steel can. If it does, then continue to use premium grade. If it does not ping using midgrade, try regular at the next fill-up and see if it pings. There is really no other reasonable way to find out.

I don’t really think using a lead substitute is needed. The valves may recess into the cylinder head if hardened seats were not installed (not likely), but to have this happen requires the engine to be operating under a heavy load and at high speeds for a long period of time. If you drive this car in hilly areas at highway speeds for hours at a time, then yes, continue to use the lead substitute, but maybe reduce it to every other tank fill-up. If the car is being driven around town at lower speeds and not under a heavy load, I don’t think there is a need to continue to use it.

Have an automotive related question? Write to Jim at jim@jameshalderman.com

Weather and Traffic